Μπαταρίες LiPo (Lithium Polymer) Πλεονεκτήματα - Μειονεκτήματα Διαφορές:
Μιάς και έμεινα πρόσφατα απο μπαταρία είπα να αλλάξω την jel japan Yuasa που είχα με μία ελαφριά μπαταρία.
Θα προσπαθήσω να παραθέσω κάποια στοιχεία για την μπαταρία που διάλεξα. Όσοι γνωρίζουν παραπάνω και θα ήθελαν να βοηθήσουν μπορούν, αν θέλουν να ρίξουν τα φώτα τους και είτε να προσθέσουν, είτε να διορθώσουν τυχόν λάθη.
Μερικά γενικά χαρακτηριστικά που βρήκα απο το wikipedia:
Lithium-ion polymer batteries, polymer lithium ion, or more commonly lithium polymer batteries (abbreviated Li-poly, Li-Pol, LiPo, LIP, PLI or LiP) are rechargeable (secondary cell) batteries.
This type has technologically evolved from lithium-ion batteries. The primary difference is that the lithium-salt electrolyte is not held in an organic solvent but in a solid polymer composite such as polyethylene oxide or polyacrylonitrile. The advantages of Li-ion polymer over the lithium-ion design include ″potentially″ lower cost of manufacture,[citation needed] adaptability to a wide variety of packaging shapes, reliability, and ruggedness, with the disadvantage of holding less charge. Lithium-ion polymer batteries started appearing in consumer electronics around 1995.
Πλεονέκτημα δηλαδή σε κόστος παραγωγής (φθηνές), πιο οικολογικές, αξιοπιστία.
The voltage of a Li-poly cell varies from about 2.7 V (discharged) to about 4.23 V (fully charged), and Li-poly cells have to be protected from overcharge by limiting the applied voltage to no more than 4.235 V per cell used in a series combination.
Κρατήστε το παραπάνω. Εδώ έχουμε ένα απο τα μειονεκτήματα (Υπερφόρτιση μπορεί να δημιουργήσει έκρηξη).
In recent years, manufacturers have been declaring upwards of 500 charge-discharge cycles before the capacity drops to 80% (see Sanyo). Another variant of Li-poly cells, the "thin film rechargeable lithium battery", has been shown to provide more than 10,000 cycles
Μία μπαταρία μολύμβου έχει γύρω στους 150 -300 κύκλους ζωής.
Πιθανά προβλήματα:
All Li-Ion cells expand at high levels of state of charge (SOC); if uncontained, this may result in delamination, and reduction of reliability and cycle life; the case of cylindrical cells provides that containment, while pouch cells, by themselves, are not contained. Therefore, to achieve the rated performance, a battery composed of pouch cells must include a strong external casing to retain its shape
Με άλλα λόγια, καλύτερα είναι να έχει σκληρό περίβλημα η μπαταρία για να μην παραμορφώνεται η μπαταρία.
Overcharging a Li-poly battery can cause an explosion or fire.
Καλό είναι να γίνει ένας έλεγχος ότι το δυναμό της μηχανής δεν ξεπερνάει τα 14,1 volt. Επιπλέον καλό είναι να την συντηρούμε - φορτίζουμε με παλμικό φορτιστή (όχι δηλ με φορτιστή αυτοκινήτου αλλά με φορτιστή με προστασία του κυκλόματος φόρτισης).
During discharge on load, the load has to be removed as soon as the voltage drops below approximately 3.0 V[citation needed] per cell (used in a series combination), or else the battery[citation needed]will subsequently no longer accept a full charge and may experience problems holding voltage under load. Li-poly batteries can be protected by circuitry that prevents over-charge and deep-discharge.
Δεν πρέπει να μένει καιρό αφόρτιστη. Καλό είναι να έχετε ένα συντηρητή.
Compared to the lithium-ion battery, Li-poly has a greater life cycle degradation rate.[citation needed]
Lithium polymer-specific chargers are required in order to avoid fire and explosion.[citation needed]
Explosions can also occur if the battery is short-circuited, as tremendous current passes through the cell in an instant. Radio-control enthusiasts take special precautions to ensure their battery leads are properly connected and insulated.[citation needed] Furthermore fires can occur if the cell or pack is punctured.
Δεν κάνει για crash test, δεν πρέπει να βραχυκυκλώσει.
They were expensive.[citation needed]
While charging the lithium polymer batteries, the individual cells in the pack should be charged evenly. For this purpose, the cells are to be charged with special chargers. This entails special care while charging the batteries in addition to incurring expenses on procuring the chargers specific to lithium polymer batteries.
Χρειάζεται κάποιος "balancer". Αρκετές μπαταρίες έχουν ειδική υποδοχή για να φορτίζεις ξεχωριστά το κάθε κελί της μπαταρίας.